background image
SPORTS PACK
SPK-TRV33
AEP Model
SERVICE MANUAL
Ver 1.0 2003. 1
SPECIFICATIONS


background image
-- 2 --
TABLE OF CONTENTS
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH
MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS
LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE
COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS
APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS
PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!
LES COMPOSANTS IDENTIFÉS PAR UNE MARQUE 0 SUR LES
DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT
CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE
REMPLACER CES COMPOSANTS QUE PAR DES PIÈSES SONY
DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU
DANS LES SUPPÉMENTS PUBLIÉS PAR SONY.
1.
Check the area of your repair for unsoldered or poorly-soldered
connections. Check the entire board surface for solder splashes
and bridges.
2.
Check the interboard wiring to ensure that no wires are
"pinched" or contact high-wattage resistors.
3.
Look for unauthorized replacement parts, particularly
transistors, that were installed during a previous repair. Point
them out to the customer and recommend their replacement.
4.
Look for parts which, through functioning, show obvious signs
of deterioration. Point them out to the customer and
recommend their replacement.
5.
Check the B+ voltage to see it is at the values specified.
6.
Flexible Circuit Board Repairing
·Keep the temperature of the soldering iron around 270°C
during repairing.
· Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
· Be careful not to apply force on the conductor when soldering
or unsoldering.
SAFETY CHECK-OUT
After correcting the original service problem, perform the following
safety checks before releasing the set to the customer.
SPK-TRV33
1.
GENERAL
Precautions ··················································································· 3
Maintenance and Precautions ······················································· 3
Troubleshooting ············································································ 3
Preparing ······················································································ 3
Using the Sports Pack ··································································· 3
Recording ····················································································· 3
When Shooting with the LCD Screen ·········································· 3
Zooming ······················································································· 3
Recording a Still Picture ······························································· 3
Recording moving pictures on
the"Memory Stick" ······································································· 3
Playing Back with the Remote Commander ································ 3
Removing the Video Camera Recorder ········································ 3
2.
REPAIR PARTS LIST
2.1
EXPLODED VIEWS ························································· 5
2-1-1. REAR CABINET SECTION ············································· 5
2-1-2. FRONT CABINET SECTION ··········································· 6
ACCESSORIES LIST ·································································· 7


background image
-- 3 --
SPK-TRV33
SECTION 1
GENERAL


background image
-- 4 --
SPK-TRV33


background image
-5-
SPK-TRV33
SECTION 2
REPAIR PARTS LIST
2.1
EXPLODED VIEWS
NOTE:
·
-XX, -X mean standardized parts, so they may
have some differences from the original one.
·
Items marked "*" are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering these
items.
·
The mechanical parts with no reference number
in the exploded views are not supplied.
The components identified by mark 0or
dotted line with mark 0 are critical for safety.
Replace only with part number specified.
Les composants identifiés par une marque
0 sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant
le numéro spécifié.
2-1-1. REAR CABINET SECTION
Ref. No.
Part No.
Description
Ref. No.
Part No.
Description
1
3-081-528-01 EYE CUP
2
3-081-527-01 CASE, REAR
3
3-976-834-01 PLATE (UPPER), BUCKLE LOCK
4
3-951-813-11 SCREW (2X6) (TYPE 2), +K
0 5
3-081-530-01 PACKING, CABINET (NOTE 1)
6
3-076-865-01 MIRROR
7
3-076-860-11 COVER, MIRROR
8
3-076-864-01 PIN, MIRROR HINGE
9
3-076-862-01 SLIDER, MIRROR
10
3-076-863-01 HOOD, MIRROR
11
3-076-866-01 BIND (2X6), TAPPING SCREW
12
3-081-529-01 BASE, MIRROR
13
3-960-764-21 BELT, GRIP
14
3-960-765-21 RING, GRIP BELT
15
3-052-424-01 SHAFT, GRIP
16
3-979-464-01 BRACKET (B), SHOULDER BELT
17
3-078-032-01 SHAFT, HINGE
18
3-078-155-01 RETAINER, GRIP
1
2
17
4
3
17
6
7
8
9
10
12
11
11
11
11
13
14
15
16
18
5
(Note 1)
(Note1) When putting grease the cabinet packing (Ref. No. 5), al-
ways
use the grease of the blue tube of the accessory. When
using the grease of the yellow tube and the grease of the
other Inc., it hurts a cabinet packing and it causes the water
leakage