DIGITAL VIDEO CAMERA
GR-DVL505UM/805UM
No. 86585
August 2000
This service manual is printed on 100% recycled paper.
COPYRIGHT
© 2000 VICTOR COMPANY OF JAPAN, LTD.
VICTOR COMPANY OF JAPAN, LIMITED
VIDEO DIVISION
Printed in Japan
S40894
SPECIFICATIONS (The specifications shown pertain specifically to the model GR-DVL505U, 805U)
Regarding service information other than these sections, refer to the GR-DVL505U, 805U service manual (No. 86550).
Also, be sure to note important safety precautions provided in the service manual.
For Connectors
S
:Y : 1 V (p-p), 75
, analog output
C : 0.29 V (p-p), 75
, analog output
AV
Video output
:1 V (p-p), 75
, analog
Audio output
: 300 mV (rms), 1 k
, analog, stereo
DV
Input/output
: 4-pin, IEEE 1394 compliant
PC (DIGITAL PHOTO)
Digital still output
: ø2.5 mm, 3-pole
JLIP/EDIT
: ø3.5 mm, 4-pole
AC Power Adapter/Charger AA-V40EN
Power requirement
: AC 110 V to 240 V`, 50 Hz/60 Hz
Power consumption
: 23 W
Output
Charge
: DC 7.2 V
, 1.2 A
VTR
: DC 6.3 V
, 1.8 A
Dimensions (W x H x D)
: 68 mm x 38 mm x 110 mm (2-11/16" x 1-1/2" x 4-3/8")
Weight
: Approx. 250 g (0.56 lbs)
Specifications shown are for SP mode unless otherwise indicated. E & O.E. Design and specifications
subject to change without notice.
Camcorder
For General
Power supply
: DC 6.3 V
(Using AC Power Adapter/Charger)
DC 7.2 V
(Using battery pack)
Power consumption
LCD monitor off, viewfinder on
: Approx. 4.3 W
LCD monitor on, viewfinder off
: Approx. 5.3 W
Video light
: Approx. 3.5 W
Dimensions (W x H x D)
: 80 mm x 96 mm x 159 mm (3-3/16" x 3-13/16" x 6-5/16")
(with the LCD monitor closed and the viewfinder pushed down)
Weight
: Approx. 580 g (1.3 lbs)
Operating temperature
:0
°C to 40°C (32°F to 104°F)
Operating humidity
: 35% to 80%
Storage temperature
: 20
°C to 50°C (4°F to 122°F)
Pickup
: 1/4" CCD
Lens
: F 1.8, f = 3.6 mm to 36 mm, 10:1 power zoom lens
Filter diameter
: ø37 mm
LCD monitor
GR-DVL805
: 3.5" diagonally measured, LCD panel/TFT active matrix system
GR-DVL505
: 3.0" diagonally measured, LCD panel/TFT active matrix system
Viewfinder
GR-DVL805
: Electronic viewfinder with 0.44" color LCD
GR-DVL505
: Electronic viewfinder with 0.24" black/white LCD
Speaker
: Monaural
For Digital Video Camera
Format
: DV format (SD mode)
Signal format
: NTSC standard
Recording/Playback format
: Video: Digital component recording
: Audio: PCM digital recording, 32 kHz 4-channel (12-bit),
48 kHz 2-channel (16-bit)
Cassette
: Mini DV cassette
Tape speed
: SP: 18.8 mm/s
LP: 12.5 mm/s
Maximum recording time
: SP: 80 min.
(using 80 min. cassette)
LP: 120 min.
For Digital Still Camera
Storage media
: Built-in flash memory, 2 Mbyte
Compression system
: JPEG (compatible)
File size
: VGA: 640 x 480 pixels
Picture quality
: 2 modes (FINE/STANDARD)
Approximate number of storable images
FINE
:30
STANDARD
:60
(AUDINAC KIT)
1
TABLE OF CONTENTS
DIFFERENT TABLE ................................................................................................................................................................ 1 to 3
4.
CHARTS AND DIAGRAMS
4.1
MAIN CIRCUIT BOARD ............................................................................................................................................. 4-1
4.2
JACK, REAR AND JUNCTION CIRCUIT BOARDS .................................................................................................. 4-7
5.
PARTS LIST
5.1
PACKING AND ACCESSORY ASSEMBLY <M1> ..................................................................................................... 5-1
5.2
FINAL ASSEMBLY <M2> ........................................................................................................................................... 5-3
5.3
ELECTRICAL PARTS LIST
MONITOR BOARD ASSEMBLY <02> ....................................................................................................................... 5-6
6.
AC POWER ADAPTER CHARGER (AA-V40EN)
6.1
CABINET ASSEMBLY <MA> ..................................................................................................................................... 6-1
6.2
SCHEMATIC DIAGRAM ............................................................................................................................................ 6-2
6.3
CIRCUIT BOARD ....................................................................................................................................................... 6-4
6.4
ELECTRICAL PARTS LIST ........................................................................................................................................ 6-5
The following table indicate main different points between models GR-DVL805U,DVL505U,DVL805UM and GR-DVL505UM.
Note:
Mark
is same as left.
AC POWER ADAPTER CHARGER
AA-V40U
AA-V40EN
LCD MONITOR
3.5"
3"
3.5"
3"
S CABLE,S-VIDEO CABLE
Optional
Provided
VIEW FINDER
Color
Black/White
Color
Black/White
GR-DVL805U
GR-DVL505U
GR-DVL805UM
GR-DVL505UM
MODEL
ITEM
1
PACKING CASE
LY31631-008B
LY31631-007B
3
POLY BAG
* LY30023-015A
LY30023-008A
9
Q.CARD(JCA)
YU10350
10
WARRANTY INF.
BT-51005-4
11
REGIST.CARD
BT-51020-2
! 29
AC POWER ADAPTER CHARGER
LY20591-001B
LY20591-011A
30
S CABLE,S-VIDEO CABLE
QAM0004-003
31
CORE FILTER
QQR0491-002
32
MINI DV TAPE
Not used
Used
The following table indicate different parts number between models GR-DVL805U,DVL505U,DVL805UM and GR-DVL505UM.
PACKING AND ACCESSORY ASSEMBLY <M1> Note: As for IB (INSTRUCTION), refer to sec. 5.
MODEL
ITEM
REF. NO.
GR-DVL805U
GR-DVL505U
GR-DVL805UM/505UM
Note:
Mark is not used.
Mark
is same as left.
Mark * reference model was also changed.
2
FINAL ASSEMBLY <M2>
MODEL
ITEM
REF. NO.
GR-DVL805U
GR-DVL805UM
GR-DVL505U
GR-DVL505UM
! 101
LOWER CASE ASSY
* LY20560-001B
LY20560-001D
* LY20560-001B
LY20560-001D
104
CASS.COVER ASSY
* LY31609-001A
LY31609-001C
* LY31609-001A
LY31609-001C
104C
BKT(E.KNOB)
* LY42173-001A
LY42173-001B
* LY42173-001A
LY42173-001B
111
UPPER CASE(3)ASSY
* LY20550-002A
LY20550-002C
* LY20550-002A
LY20550-002C
111A
SHEET(EARTH)
* LY31599-001A
* LY31599-001A
127
TOP COVER (3)
LY20552-010A
LY20552-006A
131
SPECIAL SCREW
* LY30018-084A
LY30018-079A
* LY30018-084A
LY30018-079A
139
SCREW
* LY30018-096A
QYSPSPT1725R
* LY30018-096A
QYSPSPT1725R
141
SCREW
* LY30018-084A
QYSPSGT1760R
* LY30018-084A
QYSPSGT1760R
143
SPECIAL SCREW
* LY30018-059A
LY30018-084A
* LY30018-059A
LY30018-084A
150
HOLDER(MECHA)ASSY
* LY31618-001B
LY31618-001C
* LY31618-001B
LY31618-001C
150B
SPECIAL SCREW, X4
* LY30018-056A
LY30018-0B4A
* LY30018-056A
LY30018-0B4A
214
SHEET
*
LY42583-001A
*
LY42583-001A
ELECTRONIC VIEWFINDER ASSEMBLY <M4>
MODEL
ITEM
REF. NO.
GR-DVL805U
GR-DVL805UM
GR-DVL505U
GR-DVL505UM
300
COLOR VF UNIT
* LY20596-001A
LY20596-001C
350
E.VF ASSY
LYH20136-001A
301/351
VF CASE(UPPER)ASSY
* LY31600-001A
LY31600-001C
* LY31600-001A
LY31600-001C
306/356
HINGE(VF)ASSY
* LY31602-001A
LY31602-001C
* LY31602-001B
LY31602-001C
362
HOLDER(B/W LCD)
* LY20481-001A
LY20481-002A
MONITOR ASSEMBLY <M5>
MODEL
ITEM
REF. NO.
GR-DVL805U
GR-DVL805UM
GR-DVL505U
GR-DVL505UM
! 500
MONITOR ASSY
LYH20135-006B
LYH20135-005B
! 501
MONITOR COVER ASSY
* LY20565-006A
LY20565-006B
* LY20565-005A
LY20565-005B
502
MONITOR CASE ASSY
LY20598-002A
LY20598-001A
503
HOLDER(3LCD)
* LY20566-001A
LY20566-001B
504
HOLDER(3.5/3PWB)
LY20568-001A
LY20567-001A
509
BACK LIGHT
QLL0081-001
QLL0080-001
510
LCD MODULE
QLD0096-002
QLD0118-001
MAIN BOARD ASSEMBLY <01>
MODEL
ITEM
REF. NO.
GR-DVL805U
GR-DVL805UM
GR-DVL505U
GR-DVL505UM
PW
MAIN BOARD ASSY
* YB10277F-02
YB10277F-04
* YB10277F-02
YB10277F-04
R4301 MG RESISTOR
*
NRSA6AJ-560W
*
NRSA6AJ-560W
WR3
THIN WIRE
*
YU40017-060-1
*
YU40017-060-1
OT2
SPACER(A)
* LY30029-055A
LY30029-055B
* LY30029-055A
LY30029-055B
OT3
SPACER(A)
*
LY30029-051A
*
LY30029-051A
Note:
Mark is not used.
Mark
is same as left.
Mark * reference model was also changed.
3
MODEL
ITEM
REF. NO.
GR-DVL805U
GR-DVL805UM
GR-DVL505U
GR-DVL505UM
PW1
MONITOR BOARD ASSY
YB10280G1-01
* YB10280F1-01
YB10280F1-02
Note:
Mark is not used.
Mark
is same as left.
Mark * reference model was also changed.
MODEL
ITEM
REF. NO.
GR-DVL805U
GR-DVL805UM
GR-DVL505U
GR-DVL505UM
PW2
LCD BL BOARD ASSY
YB10280B2-01
YB10280A2-01
C7501
CAPACITOR
NCZ1016-180X
NCZ1016-150X
MODEL
ITEM
REF. NO.
GR-DVL805U
GR-DVL805UM
GR-DVL505U
GR-DVL505UM
PW2
JUNCTION BOARD ASSY
* YB10278A2-01
YB10278A2-02
* YB10278A2-01
YB10278A2-02
MODEL
ITEM
REF. NO.
GR-DVL805U
GR-DVL805UM
GR-DVL505U
GR-DVL505UM
PW1
JACK BOARD ASSY
* YB10278A1-01
YB10278A1-02
* YB10278A1-01
YB10278A1-02
MODEL
ITEM
REF. NO.
GR-DVL805U
GR-DVL805UM
GR-DVL505U
GR-DVL505UM
PW3
REAR BOARD ASSY
* YB10278A3-01
YB10278C3-02
* YB10278A3-01
YB10278C3-02
MODEL
ITEM
REF. NO.
GR-DVL805U
GR-DVL805UM
GR-DVL505U
GR-DVL505UM
PW3
B/W VF BOARD ASSY
YB10280A3-01
MONITOR BOARD ASSEMBLY <02>
LCD BL BOARD ASSEMBLY <03>
JUNCTION BOARD ASSEMBLY <05>
JACK BOARD ASSEMBLY <06>
REAR BOARD ASSEMBLY <07>
B/W VF BOARD ASSEMBLY <08>
6-1
#
!REF No. PART No.
PART NAME, DESCRIPTION
-----------------------
------------------------------
----------------------------------------------------------------------------
1
6
2
RATING LABEL
MAIN &
TERMINAL ASSY <91>
4
4
3
5
5
SECTION 6
AC POWER ADAPTER CHARGER (AA-V40EN)
SAFETY PRECAUTION
Parts identified by the
! symbol are critical for safety. Replace only with specified part numbers.
6.1 CABINET ASSEMBLY <MA>
CABINET ASSEMBLY
<MA>
! 1
PTY20591-013
UPPER CASE ASSY
! 2
PTY20483-023
LOWER CASE
! 3
PTY20483-035
POWER CORD
4
YQ10531-011
SCREW,x2
5
PTY20545-055
SCREW,x3
6
PTY20591-053
SWITCH COVER