SERVICE MANUAL
DA
TA
STEREO CAR CD RECEIVER
CDC-MP33R YZ
S/M Code No. 09-017-444-3R1
REVISION
· This Service Manual is the "Revision Publishing" and replaces "Simple Manual"
CDC-MP33R <YZ>, (S/M Code No. 09-014-444-3T1).
BASIC CD MECHANISM : CDC02AW1
2
SPECIFICATIONS
RADIO SECTION
(FM)
Frequency Range: 87.5 MHz 108 MHz (50-kHz steps)
Usable Sensitivity: 12.7 dBf
50 dB Quieting Sensitivity: 17.2 dBf
IF Rejection: 80 dB
Frequency Response: 30 Hz 15,000 Hz
S/N Ratio: 63 dB
Stereo Separation: 35 dB at 1 kHz
Alternate Channel Selectivity: 70 dB
Capture Ratio: 3 dB
(MW)
Frequency Range: 531 kHz 1,602 kHz (9-kHz steps)
Usable Sensitivity: 30
µV (30 dB)
(LW)
Frequency Range: 144 kHz 288 kHz (1-kHz/9-kHz steps)
Usable Sensitivity: 30
µV (30 dB)
CD SECTION
Frequency Response: 17 Hz 20 kHz +0/3 dB
Dynamic Range: More than 80 dB
Channel Separation: More than 65 dB
S/N Ratio: More than 85 dB
Wow/Flutter: Not applicable
MP3 Decoding: MPEG 1 Audio Layer 3
AUDIO SECTION
Max. Power Output: 50 W x 4 channels
AUX IN input
Input Sensitivity (load impedance) AUX IN: 300 mV (10 k
)
GENERAL
Power-Supply Voltage: 14.4 V (11 to 16 V allowable), DC,
negative ground
Load Impedance: 4
Tone Control: Bass
± 10 dB at 100 Hz, Treble ± 10 dB at 10 kHz
Preamp Output Voltage (load impedance): 2.2 V (10 k
)
Installed Size: 182 (W) x 53 (H) x 155 (D) mm
(71/
4 (W) x 2
1/
8 (H) x 6
1/
8 (D) inches)
STEERING WHEEL REMOTE CONTROL
Dimensions: Approx. 67 (W) x 26 (H) x 27 (D) mm
(23/
4 (W) x 1
1/
16 (H) x 1
1/
8 (D) inches) (excluding holder)
Weight: Approx. 38 g (1.33 oz.) (including holder, battery)
· Design and specifications are subject to change without notice.
3
CLASS 1
LASER PRODUCT
KLASSE 1
LASER PRODUKT
LUOKAN 1
LASER LAITE
KLASS 1
LASER APPARAT
This set employs laser. Therefore, be sure to follow carefully
the instructions below when servicing.
WARNING!!
WHEN SERVICING, DO NOT APPROACH THE LASER
EXIT WITH THE EYE TOO CLOSELY. IN CASE IT IS
NECESSARY TO CONFIRM LASER BEAM EMISSION.
BE SURE TO OBSERVE FROM A DISTANCE OF MORE
THAN 30cm FROM THE SURFACE OF THE OBJEC-
TIVE LENS ON THE OPTICAL PICK-UP BLOCK.
s Caution: Invisible laser radiation when
open and interlocks defeated avoid
exposure to beam.
s Advarsel: Usynlig laserståling ved åbning,
når sikkerhedsafbrydere er ude af funktion.
Undgå udsættelse for stråling.
VAROITUS!
Laiteen Käyttäminen muulla kuin tässä käyttöohjeessa
mainitulla
tavalla
saataa
altistaa
käyt-täjän
turvallisuusluokan 1 ylittävälle näkymättömälle
lasersäteilylle.
VARNING!
Om apparaten används på annat sätt än vad som
specificeras i denna bruksanvising, kan användaren
utsättas för osynling laserstrålning, som överskrider
gränsen för laserklass 1.
PROTECTION OF EYES FROM LASER BEAM DURING SERVICING
CAUTION
Use of controls or adjustments or performance of proce-
dures other than those specified herin may result in
hazardous radiation exposure.
ATTENTION
L'utillisation de commandes, réglages ou procédures
autres que ceux spécifiés peut entraîner une dangereuse
exposition aux radiations.
ADVARSEL
Usynlig laserståling ved åbning, når sikkerhedsafbrydereer
ude af funktion. Undgå udsættelse for stråling.
This Compact Disc player is classified as a CLASS 1
LASER product.
The CLASS 1 LASER PRODUCT label is located on the
rear exterior.
Precaution to replace Optical block
(KSS-710A)
Body or clothes electrostatic potential could
ruin laser diode in the optical block. Be sure
ground body and workbench, and use care the
clothes do not touch the diode.
1) After the connection, remove solder shown in
right figure.
PICK-UP ASSY PWB
SOLDER
4
ELECTRICAL MAIN PARTS LIST
DESCRIPTION
REF. NO.
KANRI
NO.
PART NO.
DESCRIPTION
REF. NO.
KANRI
NO.
PART NO.
IC
88-KT1-607-080
C-IC,SAA6579T
8Z-KT1-622-010
C-IC,LC75374E
8B-KCF-616-010
IC,TA8273H
87-A21-532-030
C-IC,LC75817W-8720
87-A90-951-010
RCR UNIT,SBX1971-52
88-KT1-606-080
IC,PST994D
87-A20-712-040
C-IC,BA6417F
8B-KC6-621-030
C-IC,UPD178018AGC-598
87-020-784-080
IC,TC4053BF
87-A21-467-040
C-IC,CXA2581N
87-A21-533-030
C-IC,CXD2587Q
87-A21-161-040
C-IC,BA6392FP
87-A20-712-040
C-IC,BA6417F
87-A21-941-030
C-IC,UT62L1024LC-70LL
87-A21-621-010
C-IC,MAS3507D-G10
87-A21-624-040
C-IC,SN74AHC1G08 DCK
87-A21-599-010
C-IC,LC89513K
87-A21-942-030
C-IC,T15L256A-70P
87-A21-714-030
C-IC,DAC3550A-C2
87-A20-905-040
C-IC,BA033FP
87-A21-190-040
C-IC,PQ20WZ1U
87-A21-728-040
C-IC,SN74LVC07A
87-A22-017-030
C-IC,UPD784216AYGC-110-8EU
TRANSISTOR
87-A30-287-040
C-TR,DTC114TKA
87-A30-289-040
C-TR,2SA1037AK(R)
89-324-122-040
C-TR,2SC2412KR
87-A30-283-040
C-TR,DTA114YKA
87-A30-288-040
C-TR,DTC114YKA
87-A30-290-010
TR,KTA1658(Y)
86-NFZ-664-040
C-TR,DTC143TKA
87-A30-291-010
TR,KTC4369(Y)
89-418-580-080
TR,2SD1858TV2
89-423-952-010
TR,2SD2395E
87-A30-248-040
C-TR,2SB1197KQ
87-A30-011-080
C-TR,DTB113ZK
87-A30-273-040
C-TR,DTC124EKA
87-A30-455-040
C-TR,DTA144EKA
DIODE
87-A40-250-040
C-DIODE,DAN217
87-070-136-080
ZENER,MTZJ5.1B
87-020-331-040
C-DIODE,DAN202K
87-A40-817-040
C-ZENER,STZ6.8N
87-001-783-080
DIODE,1N4002
87-A40-798-010
DIODE,1N5402 (3A/200V)
87-A40-624-080
ZENER,MTZJ10A
87-A40-509-080
ZENER,MTZJ6.8C
87-020-330-040
C-DIODE,DAP202K
87-A40-620-080
ZENER,MTZJ6.2A
MAIN C.B
ANT101
8Z-KT1-614-010
ANT,AW-002
C101
87-012-274-080
C-CAP,U 1000P-50 K B
C102
87-012-286-080
C-CAP,U 0.01-25 K B
C103
87-012-282-080
C-CAP,U 4700P-50 K B
C104
87-010-498-040
CAP,E 10-16 M 5L SRE
C105
87-010-787-080
CAP,U 0.022-25 K B
C106
87-010-787-080
CAP,U 0.022-25 K B
C107
87-012-274-080
C-CAP,U 1000P-50 K B
C108
87-010-787-080
C-CAP,U 0.022-25 K B
C109
87-010-831-080
C-CAP,U 0.1-16 Z F
C110
87-012-281-080
C-CAP,U 3900P-50 B
C111
87-012-286-080
C-CAP,U 0.01-25 K B
C112
87-010-831-080
C-CAP,U 0.1-16 Z F
C114
87-010-831-080
C-CAP,U 0.1-16 Z F
C115
87-010-831-080
C-CAP,U 0.1-16 Z F
C116
87-010-495-040
CAP,E 2.2-50 M 5L SRE
C117
87-012-286-080
C-CAP,U 0.01-25 K B
C118
87-012-278-080
C-CAP,U 2200P-50 K B
C119
87-010-490-040
CAP,E 0.1-50 M 5L MA
C120
87-012-282-080
C-CAP,U 4700P-50 K B
C121
87-012-278-080
C-CAP,U 2200P-50 K B
C122
87-012-274-080
C-CAP,U 1000P-50 K B
C123
87-012-286-080
C-CAP,U 0.01-25 K B
C125
87-010-786-080
C-CAP,U 0.018-25 K B GRM
C126
87-010-786-080
C-CAP,U 0.018-25 K B GRM
C127
87-012-358-080
C-CAP,S 0.47-10 Z F CM/CB
C128
87-012-358-080
C-CAP,S 0.47-10 Z F CM/CB
C151
87-012-336-080
C-CAP,U 330P-50 J SL
C152
87-010-495-040
CAP,E 2.2-50 M 5L SRE
C153
87-012-271-080
C-CAP,U 560P-50 K B
C154
87-010-787-080
C-CAP,U 0.022-25 K B
C155
87-012-182-080
C-CAP,U 27P-50 J CH
C156
87-012-183-080
C-CAP,U 30P-50 J CH
C157
87-010-831-080
C-CAP,U 0.1-16 Z F
C158
87-010-553-040
CAP,E 47-16 M 5L SRE
C301
87-010-497-040
CAP,E 4.7-35 M 5L SRE
C302
87-010-497-040
CAP,E 4.7-35 M 5L SRE
C303
87-010-494-040
CAP,E 1-50 M 5L SRE
C304
87-010-494-040
CAP,E 1-50 M 5L SRE
C305
87-012-280-080
C-CAP,U 3300P-50 K B
C306
87-012-280-080
C-CAP,U 3300P-50 K B
C307
87-010-787-080
C-CAP,U 0.022-25 K B
C308
87-010-787-080
C-CAP,U 0.022-25 K B
C309
87-010-494-040
CAP,E 1-50 M 5L SRE
C310
87-010-494-040
CAP,E 1-50 M 5L SRE
C311
87-A12-308-080
C-CAP,S 0.15-25 K B
C312
87-A12-308-080
C-CAP,S 0.15-25 K B
C313
87-A12-308-080
C-CAP,S 0.15-25 K B
C314
87-A12-308-080
C-CAP,S 0.15-25 K B
C315
87-010-494-040
CAP,E 1-50 M 5L SRE
C316
87-010-494-040
CAP,E 1-50 M 5L SRE
C317
87-010-831-080
C-CAP,U,0.1-16 Z F
C318
87-010-498-040
CAP,E 10-16 M 5L SRE
C321
87-010-555-040
CAP,E 100-10 M 5L SRE
C322
87-010-787-080
C-CAP,U 0.022-25 K B
C323
87-010-498-040
CAP,E 10-16 M 5L SRE
C324
87-010-498-040
CAP,E 10-16 M 5L SRE
C325
87-010-498-040
CAP,E 10-16 M 5L SRE
C326
87-010-498-040
CAP,E 10-16 M 5L SRE
C341
87-010-491-040
CAP,E 0.22-50 M 5L SRE
C342
87-010-491-040
CAP,E 0.22-50 M 5L SRE
C401
87-010-494-040
CAP,E 1-50 M 5L SRE
C402
87-A10-369-080
C-CAP,S 0.47-16 K B
C403
87-A10-369-080
C-CAP,S 0.47-16 K B
C405
87-010-759-080
C-CAP,U 0.1-25 Z F
C406
87-010-759-080
C-CAP,U 0.1-25 Z F
C407
87-010-494-040
CAP,E 1-50 M 5L SRE
C408
87-010-494-040
CAP,E 1-50 M 5L SRE
C409
87-010-494-040
CAP,E 1-50 M 5L SRE
C410
87-010-494-040
CAP,E 1-50 M 5L SRE
C423
87-010-497-040
CAP,E 4.7-35 M 5L SRE
C424
87-010-497-040
CAP,E 4.7-35 M 5L SRE
C425
87-010-497-040
CAP,E 4.7-35 M 5L SRE
C426
87-010-497-040
CAP,E 4.7-35 M 5L SRE
C427
87-012-270-080
C-CAP,U 470P-50 K B
C428
87-012-270-080
C-CAP,U 470P-50 K B
C429
87-012-270-080
C-CAP,U 470P-50 K B
C430
87-012-270-080
C-CAP,U 470P-50 K B
C451
87-012-358-080
C-CAP,S 0.47-10 Z F CM/CB
C452
87-012-358-080
C-CAP,S 0.47-10 Z F CM/CB
C453
87-010-831-080
C-CAP,U 0.1-16 Z F
C454
87-012-286-080
C-CAP,U 0.01-25 K B
C461
87-010-787-080
C-CAP,U 0.022-25 K B
C501
87-012-358-080
C-CAP,S 0.47-10 Z F CM/CB
5
DESCRIPTION
REF. NO.
KANRI
NO.
PART NO.
DESCRIPTION
REF. NO.
KANRI
NO.
PART NO.
C502
87-012-358-080
C-CAP,S 0.47-10 Z F CM/CB
C503
87-012-358-080
C-CAP,S 0.47-10 Z F CM/CB
C504
87-012-358-080
C-CAP,S 0.47-10 Z F CM/CB
C505
87-012-270-080
C-CAP,U 470P-50 K B
C506
87-012-270-080
C-CAP,U 470P-50 K B
C507
87-012-270-080
C-CAP,U 470P-50 K B
C508
87-012-270-080
C-CAP,U 470P-50 K B
C510
87-010-498-040
CAP,E 10-16 M 5L SRE
C515
8A-KC7-623-000
CAP,E 2200-16 125 BT
C516
87-012-368-080
C-CAP,S 0.1-50 Z F
C517
87-012-368-080
C-CAP,S 0.1-50 Z F
C519
87-010-494-040
CAP,E 1-50 M 5L SRE
C522
87-012-368-080
C-CAP,S 0.1-50 Z F
C701
87-012-278-080
C-CAP,U 2200P-50 K B
C704
87-012-368-080
C-CAP,S 0.1-50 Z F
C705
87-012-278-080
C-CAP,U 2200P-50 K B
C706
87-010-553-040
CAP,E 47-16 M 5L SRE
C707
87-010-787-080
C-CAP,U 0.022-25 K B
C708
87-010-553-040
CAP,E 47-16 M 5L SRE
C709
87-010-759-080
C-CAP,U 0.1-25 Z F
C713
87-010-759-080
C-CAP,U 0.1-25 Z F
C714
87-010-787-080
C-CAP,U 0.022-25 K B
C715
87-010-759-080
C-CAP,U 0.1-25 Z F
C716
87-010-759-080
C-CAP,U 0.1-25 Z F
C717
87-010-759-080
C-CAP,U 0.1-25 Z F
C718
87-010-759-080
C-CAP,U 0.1-25 Z F
C719
87-010-759-080
C-CAP,U 0.1-25 Z F
C720
87-010-787-080
C-CAP,U 0.022-25 K B
C723
87-010-759-080
C-CAP,U 0.1-25 Z F
C725
87-010-553-040
CAP,E 47-16 M 5L SRE
C751
87-012-368-080
C-CAP,S 0.1-50 Z F
C752
87-012-368-080
C-CAP,S 0.1-50 Z F
C753
87-012-368-080
C-CAP,S 0.1-50 Z F
C754
87-010-553-040
CAP,E 47-16 M 5L SRE
C901
87-016-039-090
CAP,DL 0.022F-5.5 Z 70 FM
C902
87-012-358-080
C-CAP,S 0.47-10 Z F CM/CB
C903
87-010-831-080
C-CAP,U 0.1-16 Z F
C904
87-010-787-080
C-CAP,U 0.022-25 K B
C905
87-012-180-080
C-CAP,U 22P-50 J CH
C906
87-012-182-080
C-CAP,U 27P-50 J CH
C907
87-010-831-080
C-CAP,U 0.1-16 Z F
C908
87-012-282-080
C-CAP,U 4700P-50 K B
C909
87-012-274-080
C-CAP,U 1000P-50 K B
C910
87-012-195-080
C-CAP,U 100P-50 J CH
C911
87-012-195-080
C-CAP,U 100P-50 J CH
C912
87-010-787-080
C-CAP,U 0.022-25 K B
C913
87-010-787-080
C-CAP,U 0.022-25 K B
C914
87-010-831-080
C-CHIP,U 1000P-50 K B
C915
87-012-274-080
C-CAP,U 1000P-50 K B
C916
87-010-787-080
C-CAP,U 0.022-25 K B
CON401
87-A61-219-010
CONN,20P H 52089-2020
CON402
87-A61-584-010
CONN,24P H 52089-2420
CON403
87-A61-583-010
CONN,16P H 52089-1620
CON701
8A-KT1-646-010
CONN ASSY,8P ISO-WHITE-B
CON702
8A-KT1-645-010
CONN ASSY,8P ISO-BLACK-B
CON751
87-A60-670-010
CONN,6P H 2MM JMT
F701
8Z-KC1-621-010
FUSE,15A 32V
FFC401
88-KC4-641-010
FF-CABLE,20P 1.0 90MM
FFC651
8B-KC1-603-010
F-CABLE,2P (PWB LED)
J401
87-A61-224-110
JACK,PIN 4P XR-401
J402
8A-KC7-620-010
JACK,DIN 13 P SKDS1302
L101
87-003-143-080
COIL,4.7UH K LAL02
L102
8Z-KT1-619-010
COIL,68MH K7-D
L401
87-003-102-080
COIL,10UH J LAL02
L402
87-003-102-080
COIL,10UH J LAL02
L403
87-003-102-080
COIL,10UH J LAL02
L701
8B-KCF-615-010
FLTR,AMORPHOUS -CHOKE
L702
87-003-149-080
COIL,47UH J LAL02
L703
87-003-050-080
COIL,47UH K LAL04
SFR101
87-024-437-080
SFR,100K H RH063MC
TU101
8B-KC3-620-010
TU UNIT, FAE347-E21
X151
87-A70-091-010
VIB,XTAL 4.332MHZ CSA-309
X901
87-A70-175-010
VIB,XTAL 4.5MHZ AT-49
DISP C.B
C602
87-010-831-080
C-CAP,U 0.1-16 Z F
C603
87-010-831-080
C-CAP,U 0.1-16 Z F
C604
87-A10-504-080
C-CAP,U 0.047-16 K B
C605
87-012-199-080
C-CAP,U 220P-50 J CH
C606
87-A10-504-080
C-CAP,U 0.047-16 K B
C607
87-A10-504-080
C-CAP,U 0.047-16 K B
C608
87-A10-504-080
C-CAP,U 0.047-16 K B
C609
87-A10-504-080
C-CAP,U 0.047-16 K B
C610
87-010-805-080
C-CAP,S 1-16 Z F
C611
87-010-831-080
C-CAP,U 0.1-16 Z F
C612
87-010-831-080
C-CAP,U 0.1-16 Z F
C613
87-012-286-080
C-CAP,U 0.01-25 K B
CON601
87-A61-585-080
C-CONN,24P H 54548-2490
LCD701
8B-KC7-626-010
LCD,BKC-1/7
LED601
87-A91-355-040
C-LED,BR1112H-TR-RED
LED602
87-A91-355-040
C-LED,BR1112H-TR-RED
LED603
87-A91-355-040
C-LED,BR1112H-TR-RED
LED604
87-A91-355-040
C-LED,BR1112H-TR-RED
SW601
87-A90-001-080
C-SW,TACT SKQMAL
SW602
87-A90-001-080
C-SW,TACT SKQMAL
SW603
87-A90-001-080
C-SW,TACT SKQMAL
SW604
87-A90-001-080
C-SW,TACT SKQMAL
SW605
87-A90-001-080
C-SW,TACT SKQMAL
SW620
87-A90-001-080
C-SW,TACT SKQMAL
KEY C.B
C621
87-010-831-080
C-CAP,U 0.1-16 Z F
CON603
87-A61-586-080
C-CONN,16P V FLZT-SM1
L601
87-005-906-080
C-COIL,S 10.0UH K LK2125
L602
87-005-906-080
C-COIL,S 10.0UH K LK2125
L603
87-005-906-080
C-COIL,S 10.0UH K LK2125
LED611
87-A91-355-040
C-LED,BR1112H-TR-RED
LED612
87-A91-355-040
C-LED,BR1112H-TR-RED
LED613
87-A91-355-040
C-LED,BR1112H-TR-RED
LED614
87-A91-355-040
C-LED,BR1112H-TR-RED
LED615
87-A91-355-040
C-LED,BR1112H-TR-RED
LED616
87-A91-355-040
C-LED,BR1112H-TR-RED
LED617
87-A91-355-040
C-LED,BR1112H-TR-RED
LED618
87-A41-096-010
LED,E1L31-3B0A2 BLU
LED619
87-A40-813-240
C-LED,SEC1E01C BLU
LED620
87-A40-813-240
C-LED,SEC1E01C BLU
LED621
87-A40-813-240
C-LED,SEC1E01C BLU
LED622
87-A40-813-240
C-LED,SEC1E01C BLU
LED625
87-A91-355-040
C-LED,BR1112H-TR-RED
LED626
87-A91-355-040
C-LED,BR1112H-TR-RED
SW606
87-036-220-080
C-SW,TACT SKQDAA
SW607
87-036-220-080
C-SW,TACT SKQDAA
SW608
87-036-220-080
C-SW,TACT SKQDAA
SW609
87-036-220-080
C-SW,TACT SKQDAA
SW610
87-036-220-080
C-SW,TACT SKQDAA
SW611
87-036-220-080
C-SW,TACT SKQDAA
SW612
87-036-220-080
C-SW,TACT SKQDAA
SW613
87-036-220-080
C-SW,TACT SKQDAA
SW614
87-036-220-080
C-SW,TACT SKQDAA
SW615
87-036-220-080
C-SW,TACT SKQDAA
SW616
87-036-220-080
C-SW,TACT SKQDAA
SW617
87-036-220-080
C-SW,TACT SKQDAA
SW618
87-036-220-080
C-SW,TACT SKQDAA
SENS C.B
CNA751
8B-KC7-617-010
CONN ASSY,6P EMP
FFC671
8B-KC7-618-010
F-CABLE,2P MOT
M601
87-A91-054-010
MOT,FF-050SK
!