background image
DXC-D30/D30P
DIGITAL VIDEO CAMERA
SERVICE MANUAL
Vol. 1 (1st Edition/Revised 1)


background image
CAUTION
Danger of explosion if battery is incorrectly
replaced.
Replace only with the same or equivalent type
recommended by the manufacturer.
Dispose of used batteries according to the
manufacturer's instructions.
Vorsicht!
Explosionsgefahr bei unsachgemäßem
Austausch der Batterie.
Ersatz nur durch denselben oder einen vom
Hersteller empfohlenen ähnlichen Typ.
Entsorgung gebrauchter Batterien nach Angaben
des Herstellers.
ATTENTION
Il y a danger d'explosion s'il y a remplacement
incorrect de la batterie.
Remplacer uniquement avec une batterie du
même type ou d'un type équivalent recommandé
par le constructeur.
Mettre au rebut les batteries usagées
conformément aux instructions du fabricant.
ADVARSEL!
Lithiumbatteri-Eksplosionsfare ved fejlagtig
håndtering.
Udskiftning må kun ske med batteri
af samme fabrikat og type.
Levér det brugte batteri tilbage til leverandøren.
VAROITUS
Paristo voi räjähtää jos se on virheellisesti asennettu.
Vaihda paristo ainoastaan laitevalmistajan
suosittelemaan tyyppiin.
Hävitä käytetty paristo valmistajan ohjeiden
mukaisesti.
VARNING
Explosionsfara vid felaktigt batteribyte.
Använd samma batterityp eller en likvärdig typ
som rekommenderas av apparattillverkaren.
Kassera använt batteri enligt gällande
föreskrifter.
ADVARSEL
Lithiumbatteri - Eksplosjonsfare.
Ved utskifting benyttes kun batteri som
anbefalt av apparatfabrikanten.
Brukt batteri returneres
apparatleverandøren.


background image
Introducing this manual
This manual is the Service Manual Vol. 1 of the DIGITAL VIDEO CAMERA DXC-D30 and
DXC-D30P.
This manual contains the operation manual related to the operations of this equipment, the
replacement of the parts and adjustments.
Related manuals
In addition to this Service Manual Vol. 1, the following manuals are provided.
· Service Manual Vol. 2
Part No. 9-977-263-21
Contains block diagrams, board layouts, schematic diagrams, semiconductor pin assingments
and parts lists.
· Service Manual DXF-701/701CE
Part No. 9-977-265-01
See the DXF-701/701CE service manual available separately.
· Service Manual VCT-U14
Part No. 9-977-221-01
See the VCT-U14 service manual available separately.


background image
2
DXC-D30 (UC)
DXC-D30P (CE)
TABLE OF CONTENTS
1. OPERATING INSTRUCTIONS
2. SERVICE INFORMATION
2-1. BOARD LAYOUT .................................................. 2-1
2-2. REMOVAL OF CABINET ...................................... 2-1
2-2-1. Removal of Side Plate ................................. 2-1
2-2-2. Cautions on Removal of Top Chassis ......... 2-2
2-3. REPLACEMENT OF MAIN PARTS ...................... 2-2
2-3-1. Replacement of CCD Unit ........................... 2-2
2-4. CONNECTORS AND CABLES ............................ 2-4
2-4-1. Connector Input/Output Signals .................. 2-4
2-4-2. Connection Connector ................................. 2-8
2-5. HOW TO HANDLE OF AT-110 BOARD .............. 2-8
2-5-1. How to Attach of the Extention Board
EX-591 ......................................................... 2-8
2-5-2. Replacement Way of ROM(IC102) .............. 2-8
2-6. DC-DC CONVERTER VOLTAGE ........................ 2-9
2-7. SERVICE MODE OPERATION ............................ 2-10
3. ALIGNMENT
3-1. PREPARATION .................................................... 3-1
3-1-1. Equipment Required .................................... 3-1
3-1-2. Connection ................................................... 3-1
3-1-3. Switch Setting Before Adjustment ............... 3-2
3-1-4. Notes on Adjustment ................................... 3-2
3-1-5. Adjustment Item ........................................... 3-3
3-2. BEFORE ADJUSTMENT ...................................... 3-4
3-2-1. Color Bar Signal Confirmation ..................... 3-4
3-2-2. Sensitivity Measurement Confirmation ........ 3-4
3-3. CAMERA ADJUSTMENT
3-3-1. Sub-Carrier Frequency Adjustment ............. 3-5
3-3-2. INT SC-H Phase Adjustment ....................... 3-5
3-3-3. Y/R-Y/B-Y CLP Level Adjustment ............... 3-5
3-3-4. Y/SYNC/R-Y/B-Y Level Adjustment ............ 3-6
3-3-5. Carrier Balance Adjustment ........................ 3-6
3-3-6. Chroma (VBS) Level Adjustment ................ 3-7
3-3-7. Y (VBS) Level Adjustment ........................... 3-7
3-3-8. Y (YC) Level Adjustment ............................. 3-8
3-3-9. Chroma (YC) Level Adjustment ................... 3-8
3-3-10. VF SYNC/BLKG Level Adjustment .............. 3-9
3-3-11. CCD Output Level Adjustment .................... 3-9
3-3-12. Pedestal Adjustment .................................... 3-10
3-3-13. Shading Adjustment ..................................... 3-10
3-3-14. Flare Adjustment .......................................... 3-11
3-3-15. MIC LEVEL/MIC Level IND Adjustment ...... 3-11
3-3-16. Character Position Adjustment .................... 3-12
1


background image
DXC-D30(UC)
DXC-D30P(CE)
1-1
SECTION
1
OPERATING
INSTRUCTIONS
This
section
is
extracted
from
operation
manual.
Operating Instructions
Before operating the unit, please read this manual
thoroughly and retain it for future reference.
3-858-217-11(1)
Color Video Camera
DXC-D30F/D30PF
DXC-D30K/D30PK
DXC-D30L/D30PL
DXC-D30H/D30PH
© 1996 by Sony Corporation
http://getMANUAL.com