background image
MICROFILM
SERVICE MANUAL
COMPACT DISC COMPACT PLAYER
US Model
Canadian Model
AEP Model
UK Model
E Model
Australian Model
Chinese Model
D-E705/E805
Tourist Model
D-E700/E800
Model Name Using Similar Mechanism
NEW
CD Mechanism Type
CDM-2911DBA
Optical Pick-Up Name
DAX-11D
SPECIFICATIONS
D-E700/E705/E800/E805
Photo: D-E705
System
Compact disc digital audio system
Laser diode properties
Material: GaAlAs
Wavelength:
= 780 nm
Emission duration: Continuous
Laser output: Less than 44.6 µW
(This output is the value measured at a distance of 200 mm from the
objective lens surface on the optial pick-up block with 7 mm
aperture.)
Error correction
Sony Super Strategy Cross Interleave Reed Solomon Code
D-A conversion
1-bit quartz time-axis control
Frequency response
20 ­ 20,000 Hz
dB (measured by EIAJ CP-307)
Output (at 4.5 V input level)
Headphones (stereo minijack)
15 mW + 15 mW at 16 ohms
Line output (stereo minijack)
Output level 0.7 V rms at 47 kilohms
Recommended load impedance over 10 kilohms
Optical digital output (optical output connector)
Output level: ­21 to ­15 dBm
Wavelength: 630 ­ 690 nm at peak level
General
Power requirements
For the area code of the model you purchased, check the upper left
side of the bar code on the package.
· Two Sony NH-DM2AA Rechargeable batteries: 2.4 V DC
· Two LR6 (size AA) batteries: 3 V DC
· AC power adaptor (DC IN 4.5 V jack):
US, Canadian, E92 model: 120 V, 60 Hz
AEP, French, East European, E13, Chinese model: 220 ­ 230 V,
50/60 Hz
UK model: 230 ­ 240 V, 50 Hz
Australian model: 240 V, 50 Hz
Tourist, E33 model: 100 ­ 240 V, 50/60 Hz
Hong Kong model: 220 V, 50/60 Hz
· Sony DCC-E245 car battery cord for use on car battery: 4.5 V DC
Dimensions (w/h/d) (without projecting parts and controls)
D-E700/E705:
Approx. 131.8
× 23.9 × 142.0 mm
(51/4
× 31/32 × 55/8 in.)
D-E800/E805:
Approx. 131.8
× 23.7 × 142.0 mm
(51/4
× 15/16 × 55/8 in.)
Mass (without rechargeable batteries)
Approx. 210 g (7.4 oz)
Operating temperature
5°C ­ 35°C (41°F ­ 95°F)
+1
­2


background image
­ 2 ­
Flexible Circuit Board Repairing
· Keep the temperature of the soldering iron around 270 °C dur-
ing repairing.
· Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
· Be careful not to apply force on the conductor when soldering
or unsoldering.
Notes on chip component replacement
· Never reuse a disconnected chip component.
· Notice that the minus side of a tantalum capacitor may be dam-
aged by heat.
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE
!
SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE
DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ
DE FONCTIONNEMENT. NE REMPLACER CES COM-
POSANTS QUE PAR DES PIÈCES SONY DONT LES
NUMÉROS SONT DONNÉS DANS CE MANUEL OU
DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK
! OR DOTTED
LINE WITH MARK
! ON THE SCHEMATIC DIAGRAMS
AND IN THE PARTS LIST ARE CRITICAL TO SAFE
OPERATION. REPLACE THESE COMPONENTS WITH
SONY PARTS WHOSE PART NUMBERS APPEAR AS
SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUB-
LISHED BY SONY.
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous ra-
diation exposure.
This appliance is classified as a CLASS 1 LASER product.
The CLASS 1 LASER PRODUCT MARKING is located on
the rear exterior.
Supplied accessories
For the area code of the model you purchased, check the upper left side
of the bar code on the package.
D-E700/E705
AC power adaptor (1)
Headphones (1)*1
Earphones with remote control (1)*2
Rechargeable batteries (2)*3
Connecting cord (Phono plug
× 2 stereo miniplug) (1)*4
AC plug adaptor (1)*5
Battery carryng case (1)*3
Carrying case (1)
*1 Supplied with US model
*2 Not supplied with US model
*3 Not supplied with US and Canadian models
*4 Not supplied with AEP, French, East European, UK and Tourist
models
*5 Supplied with Tourist, E33, E13 and Chinese models
D-E800/E805
AC power adaptor (1)
Headphones with remote control (1)*1
Earphones with remote control (1)*2
Rechargeable batteries (2)
Connecting cord (Phono plug
× 2 stereo miniplug) (1)*3
AC plug adaptor (1)*4
Battery carryng case (1)
Carrying case (1)
*1 Supplied with US model
*2 Not supplied with US model
*3 Not supplied with AEP, UK, French and Tourist models
*4 Supplied with Tourist, E33, E13 and Chinese models
Design and specifications are subject to change without notice.
· Abbreviation
E13: 220 ­ 230 V AC area
E33: 100 ­ 240 V AC area
E92: 120 V AC area
TABLE OF CONTENTS
1.
GENERAL ................................................................... 3
2.
SERVICE NOTE ........................................................ 6
3.
DISASSEMBLY ......................................................... 7
4.
SERVICE MODE ...................................................... 8
5.
ELECTRICAL ADJUSTMENTS ......................... 9
6.
DIAGRAMS
6-1. Block Diagram ................................................................ 12
6-2. Printed Wiring Boards ..................................................... 14
6-3. Schematic Diagram ......................................................... 17
6-4. IC Pin Function Description ........................................... 29
7.
EXPLODED VIEWS ................................................ 31
8.
ELECTRICAL PARTS LIST ............................... 34


background image
­ 3 ­
SECTION 1
GENERAL
This section is extracted from
instruction manual.


background image
­ 4 ­


background image
­ 5 ­