background image
ORDER NO.
PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan
PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.
PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2007
XV-DV363
RRV3605
DVD/CD RECEIVER
XV-DV363
THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S).
This service manual should be used together with the following manual(s):
For SPECIFICATIONS and PANEL FACILITIES, refer to the operating instructions.
CONTENTS
SAFETY INFORMATION..................................................................................................................................... 2
1. CONTRAST OF MISCELLANEOUS PARTS.................................................................................................... 3
2. SCHEMATIC DIAGRAM................................................................................................................................. 14
3. PCB CONNECTION DIAGRAM ..................................................................................................................... 30
Model
Type
Power Requirement
Regional restriction
codes (Region No.)
Remarks
XV-DV363
WLXJ
AC 220 V to 240 V
3
XV-DV363
NTXJ
AC 220 V
3
XV-DV363
TDXJ/RB
AC 110 V to 240 V
2
XV-DV363
YPWXJ
AC 240 V
4
Model
Order No.
Remarks
XV-DV370/KUCXJ
RRV3592
T-ZZK JUNE 2007 printed in Japan


background image
XV-DV363
2
12
34
1
234
C
D
F
A
B
E
SAFETY INFORMATION
LASER DIODE CHARACTERISTICS
FOR DVD : MAXIMUM OUTPUT POWER : 5 mW
WAVELENGTH : 650 nm
FOR CD :
MAXIMUM OUTPUT POWER : 7 mW
WAVELENGTH : 780 nm
Additional Laser Caution
1. Laser Interlock Mechanism
· Loading switch (S101 on the LOAB Assy) is used for interlock
mechanism of the laser.
When this switch turned ON in SW2 (CLOSE) side (OPEN signal is
0 V and CLOSE signal is 3.5 V), a laser becomes the status which
can completely oscillation.
Furthermore, the laser completely oscillates in the disc judgment and
disc playback.
When player is power ON state and laser diode is not completely
oscillating, 780 nm laser diode is always oscillating by half power.
· Laser diode is driving with Q307 (650 nm LD) and Q308 (780 nm
LD) on the DVD MAIN Assy.
Therefore, when short-circuit between the emitter and collector of these
transistors or the base voltage is supplied for transistors turn on, the
laser oscillates. (failure mode)
· In the test mode
, there is the mode that the laser oscillates except
for the disc judgment and playback. LD ON mode in the test mode
oscillates with the laser forcibly.
The interlock mechanism mentioned above becomes invalid in this
mode.
2. When the cover is open, close viewing through the objective lens with
the naked eye will cause exposure to the laser beam.
LABEL CHECK
: Refer to page 25 on the service manual RRV3592.
This service manual is intended for qualified service technicians ; it is not meant for the casual do-
it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been
trained to properly and safely repair complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may
void the warranty. If you are not qualified to perform the repair of this product properly and safely,
you should not risk trying to do so and refer the repair to a qualified service technician.
WARNING!
The laser component is capable of emitting radiation exceeding
the limit for CLASS 1. A specially instructed person should do
servicing operation of the apparatus.
VRW2257
Name Label


background image
XV-DV363
3
56
7
8
56
7
8
C
D
F
A
B
E
1. CONTRAST OF MISCELLANEOUS PARTS
CONTRAST TABLE
XV-DV363/WLXJ, /NTXJ, /TDXJ/RB, /YPWXJ and XV-DV370/KUCXJ are constructed the same except for the following:
Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List.
The
mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
Screws adjacent to
mark on product are used for disassembly.
For the applying amount of lubricants or glue, follow the instructions in this manual.
(In the case of no amount instructions, apply as you think it appropriate.)
Nos. indicate the pages and Nos. in the service manual for the base model.
NOTES:
When ordering resistors, first convert resistance values into code form as shown in the following examples.
Ex.1 When there are 2 effective digits (any digit apart from 0), such as 560 ohm and 47k ohm (tolerance is shown by J=5%,
and K=10%).
Ex.2 When there are 3 effective digits (such as in high precision metal film resistors).
5 6 1
4 7 3
R 5 0
1 R 0
RD1/4PU
J
RD1/4PU
J
RN2H
K
RS1P
K
56 x 101
47 x 103
R50
1R0
561
473
RN1/4PC
F
562 x 101
5621
5
2
6
1
Mark
No.
Symbol and Description
XV-DV370
/KUCXJ
XV-DV363
/WLXJ
XV-DV363
/NTXJ
XV-DV363
/TDXJ/RB
XV-DV363
/YPWXJ
Remarks
PCB ASSEMBLIES
P51-1 DAMP Assy
XWK3318
XWK3321
XWK3321
XWK3321
XWK3321
P51-2 DVD MAIN Assy
XWM3343
XWM3357
XWM3358
XWM3360
XWM3366
>
P51-9 POWER SUPPLY Unit
XWR3014
XWR3013
XWR3013
XWR3013
XWR3013
*
1
P51-10 FM/AM TUNER Unit
AXX7250
AXX7251
AXX7251
AXX7251
AXX7251
*
1
DSP Assy
Not used
AWX8706
AWX8706
AWX8706
AWX8706
No. 1
PACKING SECTION
>
P49-1 Power Cord
ADG7021
ADG1127
ADG1127
ADG1127
ADG7099
P49-5 Remote Control
XXD3121
XXD3122
XXD3122
XXD3122
XXD3122
NSP P49-8 Warranty Card
ARY7045
Not used
XRY3004
Not used
ARY7047
P49-10 Operating Instructions
(English/French)
XRE3158
Not used
Not used
Not used
Not used
Operating Instructions
(English/Trad-Chinese)
Not used
XRE3161
Not used
Not used
Not used
Operating Instructions (Thai)
Not used
Not used
XRC3298
Not used
Not used
Operating Instructions (Arabic)
Not used
Not used
Not used
XRC3299
Not used
Operating Instructions (English)
Not used
Not used
Not used
XRB3079
XRB3087
P49-14 Setup Guide (English/French)
XRE3146
Not used
Not used
Not used
Not used
Setup Guide
(English/Trad-Chinese)
Not used
XRE3153
Not used
Not used
Not used
Setup Guide (Thai)
Not used
Not used
XRC3288
Not used
Not used
Setup Guide (English/Arabic)
Not used
Not used
Not used
XRE3154
Not used
Setup Guide (English)
Not used
Not used
Not used
Not used
XRB3085
P49-22 Packing Case
XHD3706
XHD3720
XHD3721
XHD3723
XHD3722
Microphone
(for Auto MCACC setup)
Not used
APM7008
APM7008
APM7008
APM7008
NSP
Polyethylene Bag
(For Warranty Card)
Not used
Not used
AHG7099
Not used
Not used
NSP
Service Map (Thai)
Not used
Not used
XRY3005
Not used
Not used
EXTERIOR SECTION
P51-17 Connector Assy (J1902)
PG13KK-F22
PG14KK-F22
PG14KK-F22
PG14KK-F22
PG14KK-F22
P51-23 GND Plate W5.1
ABH7241
Not used
Not used
Not used
Not used
P51-25 Rear Panel
XNC3499
XNC3502
XNC3515
XNC3517
XNC3516
P51-27 Front Panel Assy
XXG3333
XXG3338
XXG3338
XXG3338
XXG3338
NSP P51-31 Front Panel
XMB3273
XMB3277
XMB3277
XMB3277
XMB3277


background image
XV-DV363
4
12
34
1
234
C
D
F
A
B
E
Notes : The numbers in the remarks column correspond to the numbers on the "EXPLODED VIEWS".
For PCB ASSEMBLIES, Refer to "PCB PARTS LIST", "2. SCHEMATIC DIAGRAM" and "3. PCB CONNECTION DIAGRAM".
*1 : FM/AM TUNER Unit has no service parts. POWER SUPPLY Unit has no service parts.
*2 : Refer to "LABEL CHECK".
EXPLODED VIEWS
EXTERIOR SECTION
P51-35 Bonnet (for service)
XZN3192
XZN3193
XZN3193
XZN3193
XZN3193
NSP P51-38 Name Label
XAL3261
XAL3266
XAL3266
XAL3266
XAL3266
NSP P51-40 Energy Star Label
AAX8022
Not used
Not used
Not used
AAX8022
DC Fan Motor
Not used
VXM1121
VXM1121
VXM1121
VXM1121
No. 2
Heat Sink
Not used
ANH7190
ANH7190
ANH7190
ANH7190
No. 3
Spring Plate
Not used
ABH7244
ABH7244
ABH7244
ABH7244
No. 4
Control Label
Not used
XAX3620
XAX3620
XAX3620
XAX3620
No. 5
Laser Caution
Not used
VRW2257
VRW2257
VRW2257
VRW2257
*
2
Mark
No.
Symbol and Description
XV-DV370
/KUCXJ
XV-DV363
/WLXJ
XV-DV363
/NTXJ
XV-DV363
/TDXJ/RB
XV-DV363
/YPWXJ
Remarks
Cleaning paper
: GED-008
Screw BBZ30P080FNI
Rear Panel
Screw BBZ30P080FNI
1
DVD MAIN ASSY
2
5
3
4
4
DAMP ASSY
Power Supply Unit
F
J
C
F
B F
I F
Screw
BBZ30P080FNI


background image
XV-DV363
5
56
7
8
56
7
8
C
D
F
A
B
E
PCB PARTS LIST
CONTRAST OF PCB ASSEMBLIES
XWM3358, XWM3360, XWM3366 and XWM3357 are constructed the same except for the following:
PCB PARTS LIST
BF DVD MAIN ASSY
Mark
Symbol and Description
XWM3357
XWM3358
XWM3360
XWM3366
Remarks
R5513
RD1/4PU473J RD1/4PU393J RD1/4PU104J RD1/4PU223J
R5515
Not used
RD1/4PU223J RD1/4PU103J RD1/4PU473J
Mark No.
Description
Part No.
BF DVD MAIN ASSY (XWM3357)
MISCELLANEOUS
IC 101 (A,41,32) 6CH DRIVER IC
BD7995EFS
IC 201 (A,77,112) DVD IC
MT1389FE/H-L
IC 202 (A,110,99) IC
K4S641632K-UC75
IC 203 (A,72,77) FLASH ROM
AYW7154
IC
FLASH MEMORY IC
S29AL016D70TFI010
IC 204 (A,93,79) EEPROM
S-24CS64A0I
IC 401 (A,103,145) DVD VIDEO AMP IC
MM1758XF
>
IC 771 (A,34,50) LOAD SWITCHING
AAT4618IGV-0.5-1
>
IC 781 (A,51,49) REGULATOR IC
NJM2845DL1-05
IC 931 (A,102,195) HDMI IC
MT1392E/C-L
>
IC 981 (A,84,160) REGULATOR IC
NJM2872BF05
>
IC 1101 (A,20,110) REGULATOR IC
NJM2846DL3-18
IC 3001 (A,41,151) IC
TC4052BFN
>
IC 3002 (A,16,147) REGULATOR IC
NJM2872BF25
IC 3003 (A,23,145) AD CONVERTER IC
AK5358AET
IC 3901 (A,83,200) DUAL OP-AMP
NJM4565MD
IC 5501 (A,83,44) SYSTEM CONTROL MICON
PDC154A
IC 5502 (A,111,37) EEPROM
S-93C46BD0I-J8T1
Q 304 (A,13,35) TRANSISTOR
2SC4154
Q 305 (A,14,41) NMOS FET TRANSISTOR
UM5K1N
Q 307 (A,11,61) CHIP TRANSISTOR
HN1A01F
Q 308 (A,16,61) CHIP TRANSISTOR
HN1A01F
Q 933 (A,114,212) TRANSISTOR
RT1N144M
Q 934 (A,115,216) TRANSISTOR
RT3P22M
Q 1201 (A,24,101) TRANSISTOR
RT1N141M-11
Q 1202 (A,30,106) CHIP TRANSISTOR
RSR015P03
Q 1301 (A,13,102) TRANSISTOR(SC-70)
2SA1602A
Q 1302 (A,17,102) TRANSISTOR
2SA1577
Q 1303 (A,13,96) TRANSISTOR
2SC4154
Q 1304 (A,18,92) TRANSISTOR
2SC4154
Q 1402 (A,110,25) TRANSISTOR(SC-70)
2SA1602A
Q 1413 (A,106,21) TRANSISTOR
RT1N241M
Q 3005 (A,42,140) CHIP TRANSISTOR
HN1A01FU
Q 3006 (A,8,200) TRANSISTOR
RT1N241M
Q 3951 (A,46,64) TRANSISTOR
RT1N241M
Q 5525 (A,62,59) DIGITAL TR(SC-70)
RT1N431M
Q 5531 (A,97,11) TRANSISTOR
RT3N22M
Q 5532 (A,97,7) TRANSISTOR
RT1N241M
Q 5533 (A,91,5) DIGITAL TR(SC-70)
RT1P241M
Q 5601 (A,102,68) TRANSISTOR(SC-70)
2SA1602A
Q 5602 (A,93,68) CHIP TRANSISTOR
HN1C01FU
Q 5703 (A,74,187) CHIP TRANSISTOR
HN1C01FU
Q 5931 (A,86,211) TRANSISTOR
RT1N241M
Q 5932 (A,76,211) TRANSISTOR
RT3N22M
Q 5934 (A,83,211) TRANSISTOR(SC-70)
2SA1602A
Q 5935 (A,71,213) TRANSISTOR(SC-70)
2SA1602A
Q 5936 (A,78,215) DIGITAL TR(SC-70)
RT1P241M
Q 5941 (A,21,192) TRANSISTOR
RT1N241M
D 802 (A,61,24) DIODE
1SS352
D 933 (A,112,204) DIODE
UDZS5R1(B)
D 1201 (A,27,103) DIODE
1SS352
D 1403 (A,110,30) DIODE
MC2846-11
D 1416 (A,98,23) DIODE
1SS352
D 1417 (A,96,23) DIODE
1SS352
D 3901 (A,82,204) DIODE
UDZS5R1(B)
D 3902 (A,59,163) DIODE
UDZS3R9(B)
D 3903 (A,58,156) DIODE
UDZS3R9(B)
D 5601 (A,101,66) DIODE
1SS352
D 5931 (A,85,218) DIODE
1SS352
D 5933 (A,74,218) DIODE
1SS352
D 5936 (A,79,212) DIODE
1SS352
D 5941 (A,21,195) DIODE
1SS352
D 5942 (A,25,188) DIODE
1SS352
L 421 (A,7,215) INDUCTOR
CTF1389
L 422 (A,26,209) INDUCTOR
CTF1389
L 761 (A,51,98) COIL
VTH1047
L 772 (A,39,50) CHIP SOLID INDUCTOR
ATL7002
L 931 (A,95,171) CHIP BEADS
ATL7010
L 932 (A,97,216) COIL
ATH7022
L 933 (A,100,216) COIL
ATH7022
L 934 (A,102,216) COIL
ATH7022
L 935 (A,105,216) COIL
ATH7022
L 936 (A,93,171) CHIP BEADS
ATL7010
L 937 (A,100,169) CHIP BEADS
ATL7010
L 1305 (A,16,105) INDUCTOR
CTF1395
L 1501 (A,58,42) AXIAL INDUCTOR
LAU220J
L 3901 (A,90,215) INDUCTOR
CTF1379
L 3951 (A,40,65) INDUCTOR
CTF1346
L 3952 (A,38,65) INDUCTOR
CTF1346
L 5931 (A,85,221) CHIP SOLID INDUCTOR
QTL1013
L 5932 (A,81,217) CHIP SOLID INDUCTOR
QTL1013
L 5933 (A,75,220) CHIP SOLID INDUCTOR
QTL1013
L 5934 (A,73,215) CHIP SOLID INDUCTOR
QTL1013
JA 401 (A,38,232) JACK
VKB1178
JA 402 (A,20,232) JACK
XKB3061
JA 931 HDMI CONNECTOR
AKP1318
JA 3901 (A,90,230) JACK
RKN1004
JA 5931 (A,80,231) MINI JACK(4P) /W SW
XKN3015
X 201 (A,75,140) CRYSTAL RESONATOR
VSS1168
(27 MHz)
X 5501 (A,64,44) CERAMIC RESONATOR
ASS7034
(10 MHz)
CN 101 (A,21,41) CONNECTOR
VKN2045
Mark No.
Description
Part No.