DIGITAL VIDEO CAMERA
GR-DVL300UM
SPECIFICATIONS (The specifications shown pertain specifically to the model GR-DVL300UM)
No. 86584
August 2000
This service manual is printed on 100% recycled paper.
COPYRIGHT
© 2000 VICTOR COMPANY OF JAPAN, LTD.
Regarding service information other than these sections, refer to the GR-DVL300U service manual (No. 86551).
Also, be sure to note important safety precautions provided in the service manual.
VICTOR COMPANY OF JAPAN, LIMITED
VIDEO DIVISION
Printed in Japan
S40894
Camcorder
For General
Power supply
: DC 6.3 V
(Using AC Power Adapter/Charger)
DC 7.2 V
(Using battery pack)
Power consumption
LCD monitor off, viewfinder on : Approx. 4.3 W
LCD monitor on, viewfinder off : Approx. 5.3 W
Video light
: Approx. 3.5 W
Dimensions (W x H x D)
: 80 mm x 96 mm x 159 mm
(with the LCD monitor closed and the viewfinder pushed down)
Weight
: Approx. 570 g (1.3 lbs)
Operating temperature
:0
°C to 40°C
Operating humidity
: 35% to 80%
Storage temperature
: 20
°C to 50°C
Pickup
: 1/4" CCD
Lens
: F 1.8, f = 3.6 mm to 36 mm, 10:1 power zoom lens
Filter diameter
: ø37 mm
LCD monitor
: 2.5" diagonally measured, LCD panel/TFT active matrix system
Viewfinder
: Electronic viewfinder with 0.24" black/white LCD
Speaker
: Monaural
For Digital Video Camera
Format
: DV format (SD mode)
Signal format
: NTSC standard
Recording/Playback format
: Video: Digital component recording
: Audio: PCM digital recording, 32 kHz 4-channel (12-bit),
48 kHz 2-channel (16-bit)
For Connectors
S
:Y : 1 V (p-p), 75
, analog output
C : 0.29 V (p-p), 75
, analog output
AV
Video output
:1 V (p-p), 75
, analog
Audio output
: 300 mV (rms), 1 k
, analog, stereo
DV
Input/output
: 4-pin, IEEE 1394 compliant
PC (DIGITAL PHOTO)
Digital still output
: ø2.5 mm, 3-pole
JLIP/EDIT
: ø3.5 mm, 4-pole
AC Power Adapter/Charger AA-V40EN
Power requirement
: AC 110 V to 220 V`, 60 Hz
Power consumption
: 23 W
Output
Charge
: DC 7.2 V
, 1.2 A
VTR
: DC 6.3 V
, 1.8 A
Dimensions (W x H x D)
: 68 mm x 38 mm x 110 mm
Weight
: Approx. 250 g
Specifications shown are for SP mode unless otherwise indicated. E & O.E. Design and specifications
subject to change without notice.
Cassette
: Mini DV cassette
Tape speed
: SP: 18.8 mm/s
LP: 12.5 mm/s
Maximum recording time
: SP: 80 min.
(using 80 min. cassette)
LP: 120 min.
(AUDINAC KIT)
TABLE OF CONTENTS
DIFFERENT TABLE ................................................................................................................................................................ 1 to 3
4.
CHARTS AND DIAGRAMS
4.1
JACK,REAR AND JUNCTION CIRCUIT BOARDS ................................................................................................... 4-1
5.
PARTS LIST
5.1
PACKING AND ACCESSORY ASSEMBLY <M1> ..................................................................................................... 5-1
5.2
FINAL ASSEMBLY <M2> ........................................................................................................................................... 5-3
6.
AC POWER ADAPTER CHARGER (AA-V40EN)
6.1
CABINET ASSEMBLY <MA> ..................................................................................................................................... 6-1
6.2
SCHEMATIC DIAGRAM ............................................................................................................................................ 6-2
6.3
CIRCUIT BOARD ....................................................................................................................................................... 6-4
6.4
ELECTRICAL PARTS LIST ........................................................................................................................................ 6-5
1
AC POWER ADAPTER CHARGER
AA-V40U
AA-V40EN
S CABLE, S-VIDEO CABLE
Optional
Provided
The following table indicate main different points between models GR-DVL300U and GR-DVL300UM.
GR-DVL300U
GR-DVL300UM
MODEL
ITEM
The following table indicate different parts number between models GR-DVL300U and GR-DVL300UM.
PACKING AND ACCESSORY ASSEMBLY <M1> Note: As for IB (INSTRUCTIONS), refer to sec.5.
1
PACKING CASE
LY31631-005A
3
POLY BAG
*
LY30023-015A
LY30023-008A
9
Q.CARD(JCA)
YU10350
10
WARRANTY INF.
BT-51005-4
11
REGIST. CARD
BT-51020-2
!
29
AC POWER ADAPTER CHARGER
LY20591-001B
LY20591-011A
30
S CABLE, S-VIDEO CABLE
QAM0004-003
31
CORE FILTER
QQR0491-002
32
MINI DV TAPE
Not used
Used
GR-DVL300U
GR-DVL300UM
MODEL
ITEM
REF NO.
FINAL ASSEMBLY <M2>
! 101
LOWER CASE ASSY
* LY20560-001B
LY20560-001C
104
CASS.COVER ASSY
* LY31609-001A
LY31609-001C
104C
BKT (E.KNOB)
* LY42173-001A
LY42173-001B
111
UPPER CASE (2.5) ASSY
* LY20557-001A
LY20557-001E
111A
SHEET (EARTH)
* LY31599-001A
111C
SPACER, X2
* LY40664-002A
LY40664-001A
131
SPECIAL SCREW
* LY30018-084A
LY30018-079A
139
SCREW
* LY30018-096A
QYSPSPT1725R
141
SCREW
* LY30018-084A
QYSPSGT1760R
143
SPECIAL SCREW
* LY30018-059A
LY30018-084A
150
HOLDER (MECHA) ASSY
* LY31618-001A
LY31618-001C
150B
SPECIAL SCREW, X4
* LY30018-056A
LY30018-0B4A
214
SHEET
*
LY42583-001A
GR-DVL300U
GR-DVL300UM
MODEL
ITEM
REF NO.
Note:
Mark is not used.
Mark * reference model was also changed.
2
ELECTRONIC VIEWFINDER ASSEMBLY <M4>
351
VF CASE(UPPER)ASSY
* LY31600-001A
LY31600-001C
356
HINGE(VF)ASSY
* LY31602-001B
LY31602-001C
362
HOLDER(B/W LCD)
* LY20481-001A
LY20481-002A
GR-DVL300U
GR-DVL300UM
MODEL
ITEM
REF NO.
MONITOR ASSEMBLY <M5>
! 500
MONITOR ASSY
* LYH20135-003A
LYH20135-003C
! 501
MONITOR COVER ASSY
* LY20569-001A
LY20569-001B
GR-DVL300U
GR-DVL300UM
MODEL
ITEM
REF NO.
MAIN BOARD ASSEMBLY <01>
PW
MAIN BOARD ASSY
* YB10277E-01
YB10277E-02
R4207
MG RESISTOR
* NASA6AJ-473W
NRSA6AJ-243W
R4301
MG RESISTOR
* NASA6AJ-100W
R4354
MG RESISTOR
* NASA6AJ-0R0W
NASA6AJ-272W
R4355
R5509
R5510
MG RESISTOR
* NASA6AJ-100W
NASA6AJ-470W
R5511
RA4304
RA4305
NETWORK RESISTOR
* NRZ0034-100W
RA4306
OT2
SPACER (A)
* LY30029-055A
LY30029-055B
GR-DVL300U
GR-DVL300UM
MODEL
ITEM
REF NO.
MONITOR BOARD ASSEMBLY <02>
PW1
MONITOR BOARD ASSY
* YB10280E1-01
YB10280E1-02
IC7101
IC
* PCVVQ110BFB
XCVVQ110CFB
R7109
CMF RESISTOR
*
NRVA63D-393X
R7110
CMF RESISTOR
*
NRVA63D-183X
R7114
MG RESISTOR
* NRSA63J-223X
NRSA63J-153X
R7119
MG RESISTOR
*
NRSA63J-333X
R7121
MG RESISTOR
* NRSA63J-473X
VR7101
TRIM RESISTOR, GAIN
* NVP0016-223X
VR7103
TRIM RESISTOR, GAMMA
*
NVP0016-223X
C7118
T CAPACITOR
* NBP41CM-106X
GR-DVL300U
GR-DVL300UM
MODEL
ITEM
REF NO.
Note:
Mark is not used.
Mark * reference model was also changed.
CCD BOARD ASSEMBLY <04>
OT1
SPACER-A
* LY30016-0U4B
OT2
L1
FERRITE CORE
* QQR0895-013
GR-DVL300U
GR-DVL300UM
MODEL
ITEM
REF NO.
JUNCTION BOARD ASSEMBLY <05>
PW2
JUNCTION BOARD ASSY
* YB10278A2-01
YB10278A2-02
GR-DVL300U
GR-DVL300UM
MODEL
ITEM
REF NO.
JACK BOARD ASSEMBLY <06>
PW1
JACK BOARD ASSY
* YB10278A1-01
YB10278A1-02
GR-DVL300U
GR-DVL300UM
MODEL
ITEM
REF NO.
REAR BOARD ASSEMBLY <07>
PW3
REAR BOARD ASSY
* YB10278A3-01
YB10278C3-02
R551
MG RESISTOR
* NRSA63J-0R0X
NRSA63J-331X
R552
GR-DVL300U
GR-DVL300UM
MODEL
ITEM
REF NO.
Note:
Mark is not used.
Mark * reference model was also changed.
3
6-1
#
!REF No. PART No.
PART NAME, DESCRIPTION
-----------------------
------------------------------
----------------------------------------------------------------------------
1
6
2
RATING LABEL
MAIN &
TERMINAL ASSY <91>
4
4
3
5
5
SECTION 6
AC POWER ADAPTER CHARGER (AA-V40EN)
SAFETY PRECAUTION
Parts identified by the
! symbol are critical for safety. Replace only with specified part numbers.
6.1 CABINET ASSEMBLY <MA>
CABINET ASSEMBLY
<MA>
! 1
PTY20591-013
UPPER CASE ASSY
! 2
PTY20483-023
LOWER CASE
! 3
PTY20483-035
POWER CORD
4
YQ10531-011
SCREW,x2
5
PTY20545-055
SCREW,x3
6
PTY20591-053
SWITCH COVER