SERVICE MANUAL
DA
TA
BASIC TAPE MECHANISM : TN-715-DH-116
STEREO CAR
CASSETTE RECEIVER
CT-Z110
S/M Code No. 09-005-344-9R1
YJ(S)
REVISION
This Service Manual is the "Revision Publishing" and replaces "Simple Manual"
(S/M Code No. 09-005-344-9T1).
2
REF. NO
PART NO.
KANRI
DESCRIPTION
NO.
ACCESSORIES LIST
1
8A-KTH-902-010
IB,Y(E CH A) 110
2
8A-KT5-908-010
IB,INST,YH,Y (E CK CH A)-A
3
86-KT1-237-010
HLDR,REAR MTG
4
87-B10-141-010
NUT,5 TYPE-2
5
87-B10-143-010
UT1+5-15 W/O SLOT
6
87-B10-144-010
W,5.2-10-0.5
7
87-B10-145-010
W-SPR,5.3-8.5-1.5
8
88-KT1-247-010
S-SCREW,HEXAGON
9
8Z-KT1-231-010
HLDR,HALF -T
10
8Z-KT1-232-010
KEY,REMOVE -T
11
8Z-KT1-251-010
S-SCREW,5*6 TH+ TAPPING ST
12
8Z-KT1-625-010
CONN ASSY,16P SOC016
SPECIFICATIONS
RADIO SECTION
(FM)
Frequency Range:
87.5 MHz108 MHz
(50-kHz steps)
87.5 MHz-108 MHz
(100-kHz steps)
Usable Sensitivity:
12.7 dBf
50 dB Quieting Sensitivity:
17.2 dBf
IF Rejection:
80 dB
Frequency Response:
30 Hz-15,000 Hz
S/N Ratio:
63 dB
Stereo Separation:
35 dB at 1 kHz
Alternate Channel Selectivity:
70 dB
Capture Ratio:
3 dB
(AM)
Frequency Range:
531 kHz1,602 kHz
(9-kHz steps)
530 kHz1,710 kHz
(10-kHz steps)
Usable Sensitivity:
30
µV (30 dB)
TAPE SECTION
Tape Speed:
4.8 cm/sec. (17/8 ips)
S/N Ratio:
50 dB
Frequency Response:
40 Hz14,000 Hz
Stereo Separation:
40 dB
FF/REW Time:
190 sec. (C-60)
AUDIO SECTION
Max. Power Output:
35 W x 4 channels
AUX IN input
Input sensitivity (load impedance)
AUX:
300 mV (10 k
)
GENERAL
Power-Supply Voltage:
14.4 V (11 to 16 V allowable),
DC, negative ground
Load Impedance:
4
Tone Control:
Bass
± 10 dB at 100 Hz
Treble
± 10 dB at 10 kHz
Installation size:
182(W) x 53(H) x 155(D) mm
(71/4(W) x 21/8(H) x 61/8(D) inches)
· Design and specifications are subject to change without notice.
3
REF. NO
PART NO.
KANRI
DESCRIPTION
NO.
REF. NO
PART NO.
KANRI
DESCRIPTION
NO.
ELECTRICAL MAIN PARTS LIST
IC
87-A21-191-010
IC,KIA6225S
8Z-KT1-622-010
C-IC,LC75374E
8Z-KTG-622-010
IC,TA8259H
87-A21-540-030
C-IC,LC72336-9911
TRANSISTOR
87-A30-473-080
TR,KRC102M-AT
8Z-KTH-622-080
TR,KTC3198Y
8Z-KTH-623-080
TR,KTA1267Y
87-A30-295-010
TR,KRA226M
8Z-KTH-627-080
TR,KTA1273Y
87-A30-475-080
TR,KRA104M-AT
8Z-KTH-626-080
TR,KTC3203Y
87-A30-476-010
TR,KTA1046Y
89-423-953-010
TR,2SD2395F
87-026-313-080
TR,DTC343TS
87-A30-467-040
C-TR,KRA111S-RTK
87-A30-468-040
C-TR,KRC102S-RTK
87-A30-469-040
C-TR,KRC111S-RTK
87-A30-472-040
C-TR,KRA226S-RTK
DIODE
87-020-465-080
DIODE,1SS133 (110MA)
87-001-783-080
DIODE,1N4002
87-A40-509-080
ZENER,MTZJ 6.8C
87-070-022-010
DIODE,IN5402 (RECT)
87-A40-344-080
ZENER,MTZJ6.2C
87-070-334-080
ZENER,MTZJ10B
87-A40-337-080
ZENER,MTZJ 6.8B
87-A40-523-080
ZENER,MTZJ9.1B
87-A40-256-080
DIODE,RB441Q40
MAIN C.B
C101
87-018-119-080
CAP, CER 100P-50V
C102
87-018-134-080
CAPACITOR,TC-U 0.01-16
C103
87-018-134-080
CAPACITOR,TC-U 0.01-16
C104
87-018-209-080
CAP, CER 0.1-50V
C105
87-018-134-080
CAPACITOR,TC-U 0.01-16
C106
87-010-402-080
CAP, ELECT 2.2-50V
C107
87-010-380-080
CAP, ELECT 47-16V
C108
87-010-380-080
CAP, ELECT 47-16V
C109
87-018-209-080
CAP, CER 0.1-50V
C114
87-018-134-080
CAPACITOR,TC-U 0.01-16
C115
87-010-380-080
CAP, ELECT 47-16V
C116
87-018-209-080
CAP, CER 0.1-50V
C117
87-018-209-080
CAP, CER 0.1-50V
C118
87-018-134-080
CAPACITOR,TC-U 0.01-16
C119
87-010-992-080
C-CAP,S 0.047-25 B
C120
87-010-992-080
C-CAP,S 0.047-25 B
C201
87-018-131-080
CAP, CER 1000P-50V
C202
87-018-131-080
CAP, CER 1000P-50V
C203
87-010-378-080
CAP, ELECT 10-16V
C204
87-010-378-080
CAP, ELECT 10-16V
C205
87-010-248-080
CAP, ELECT 220-10V
C206
87-010-248-080
CAP, ELECT 220-10V
C207
87-010-198-080
CAP, CHIP 0.022
C208
87-010-198-080
CAP, CHIP 0.022
C209
87-010-263-080
CAP, ELECT 100-10V
C210
87-010-401-080
CAP, ELECT 1-50V
C211
87-010-401-080
CAP, ELECT 1-50V
C212
87-010-380-080
CAP, ELECT 47-16V
C301
87-018-131-080
CAP, CER 1000P-50V
C302
87-018-131-080
CAP, CER 1000P-50V
C303
87-010-401-080
CAP, ELECT 1-50V
C304
87-010-401-080
CAP, ELECT 1-50V
C401
87-010-401-080
CAP, ELECT 1-50V
C402
87-010-401-080
CAP, ELECT 1-50V
C403
87-010-401-080
CAP, ELECT 1-50V
C404
87-010-401-080
CAP, ELECT 1-50V
C405
87-010-184-080
CHIP CAPACITOR 3300P(K)
C406
87-010-184-080
CHIP CAPACITOR 3300P(K)
C407
87-010-198-080
CAP, CHIP 0.022
C408
87-010-198-080
CAP, CHIP 0.022
C409
87-010-378-080
CAP, ELECT 10-16V
C410
87-010-378-080
CAP, ELECT 10-16V
C411
87-016-083-080
C-CAP,S 0.15-16 RK
C412
87-016-083-080
C-CAP,S 0.15-16 RK
C413
87-016-083-080
C-CAP,S 0.15-16 RK
C414
87-016-083-080
C-CAP,S 0.15-16 RK
C415
87-010-378-080
CAP, ELECT 10-16V
C416
87-010-378-080
CAP, ELECT 10-16V
C417
87-010-380-080
CAP, ELECT 47-16V
C418
87-010-196-080
CHIP CAPACITOR,0.1-25
C419
87-010-378-080
CAP, ELECT 10-16V
C420
87-010-401-080
CAP, ELECT 1-50V
C421
87-010-401-080
CAP, ELECT 1-50V
C422
87-010-401-080
CAP, ELECT 1-50V
C423
87-010-401-080
CAP, ELECT 1-50V
C424
87-010-196-080
CHIP CAPACITOR,0.1-25
C425
87-010-196-080
CHIP CAPACITOR,0.1-25
C501
87-016-083-080
C-CAP,S 0.15-16 RK
C502
87-016-083-080
C-CAP,S 0.15-16 RK
C503
87-016-083-080
C-CAP,S 0.15-16 RK
C504
87-016-083-080
C-CAP,S 0.15-16 RK
C505
87-018-196-080
CAP, CER 1500P-16V
C506
87-018-196-080
CAP, CER 1500P-16V
C507
87-018-196-080
CAP, CER 1500P-16V
C508
87-018-196-080
CAP, CER 1500P-16V
C509
87-010-404-080
CAP, ELECT 4.7-50
C510
87-018-209-080
CAP, CER 0.1-50V
C511
8A-KC7-623-000
CAP,E 2200U-16 PW
C512
87-010-401-080
CAP, ELECT 1-50V
C513
87-010-401-080
CAP, ELECT 1-50V
C520
87-010-182-080
C-CAP,S 2200P-50 B
C521
87-010-182-080
C-CAP,S 2200P-50 B
C601
87-018-209-080
CAP, CER 0.1-50V
C602
87-010-379-080
CAP, ELECT 22-16V
C604
87-018-209-080
CAP, CER 0.1-50V
C605
87-010-379-080
CAP, ELECT 22-16V
C606
87-010-380-080
CAP, ELECT 47-16V
C607
87-010-263-080
CAP, ELECT 100-10V
C701
87-010-314-080
C-CAP,S 22P-50V
C702
87-010-197-080
CAP, CHIP 0.01 DM
C703
87-010-263-080
CAP, ELECT 100-10V
C704
87-010-198-080
CAP, CHIP 0.022
C705
87-010-313-080
CAP, CHIP 18P
C706
87-010-315-080
C-CAP,S 27P-50 CH
C707
87-018-131-080
CAP, CER 1000P-50V
C708
87-010-401-080
CAP, ELECT 1-50
C712
87-018-208-010
CAP,TC-U 0.047-50 F
C713
87-018-208-010
CAP,TC-U 0.047-50 F
C801
87-018-134-080
CAPACITOR,TC-U 0.047
C802
87-018-134-080
CAPACITOR,TC-U 0.047
CNA201
8Z-KTH-652-010
CONN ASSY,3P (HEAD)
CNA202
8Z-KTH-651-010
CONN ASSY,8P (DECK)
CON201
87-009-031-010
CONNECTOR, 3P
CON202
87-099-408-010
CONN,8P EH V WHT
CON301
8Z-KTH-612-010
CONN,3P HEADER-STRAIGHT
CON601
8Z-KT1-624-010
CONN,16P SOC017
!F601
8Z-KC1-621-010
FUSE,15A
J101
8Z-KT1-614-010
ANT,AW-002
L101
87-003-143-080
COIL 4.7 UH
L102
8Z-KT1-619-010
COIL,68MH K7-D
L301
87-003-143-080
COIL 4.7 UH
L601
8Z-KT1-615-010
FLTR,AMORPHOUS -CHOKE
L701
87-A50-375-010
COIL,1UH K LAL02
4
REF. NO
PART NO.
KANRI
DESCRIPTION
NO.
88
A
Resistor Code
Chip Resistor Part Coding
Figure
Value of resistor
Chip resistor
Wattage
Type
Tolerance
1/16W
1/10W
1/8W
1608
2125
3216
5%
5%
5%
CJ
CJ
CJ
Form
LW
t
1.6
0.8
0.45
2
1.25
0.45
3.2
1.6
108
118
128
: A
: A
CHIP RESISTOR PART CODE
0.55
Resistor Code
Dimensions (mm)
Symbol
1/16W
1005
5%
CJ
1.0
0.5
0.35
104
L
t
W
L702
87-003-149-080
COIL,47UH
SW901
87-A91-152-010
SW,SL 1-1-2 SSSS212-11-A
TUN101
8A-KC8-624-010
TU UNIT, FAE347-A16
X701
87-A70-175-010
VIB,XTAL 4.5MHZ AT-49
FRONT C.B
D801
87-017-827-070
C-LED,SEC1201C,RED
D802
87-017-827-070
C-LED,SEC1201C,RED
D803
87-017-827-070
C-LED,SEC1201C,RED
D804
87-A40-813-040
C-LED,SEC1E01C BLUE
D805
87-A40-813-040
C-LED,SEC1E01C BLUE
D806
87-A40-813-040
C-LED,SEC1E01C BLUE
LCD801
8A-KTG-612-010
LCD,AKT-17
PL801
8A-KT7-655-010
LAMP,9V-50MA
PL802
8A-KT7-655-010
LAMP,9V-50MA
SW801
87-036-251-080
SW,T CT 6X3.5 160
SW802
87-036-251-080
SW,T CT 6X3.5 160
SW803
87-036-251-080
SW,T CT 6X3.5 160
SW804
87-036-251-080
SW,T CT 6X3.5 160
SW805
87-036-251-080
SW,T CT 6X3.5 160
SW806
87-036-251-080
SW,T CT 6X3.5 160
SW807
87-036-251-080
SW,T CT 6X3.5 160
SW808
87-036-251-080
SW,T CT 6X3.5 160
SW809
87-036-251-080
SW,T CT 6X3.5 160
SW810
87-036-251-080
SW,T CT 6X3.5 160
SW811
87-036-251-080
SW,T CT 6X3.5 160
SW812
87-036-251-080
SW,T CT 6X3.5 160
SW813
87-036-251-080
SW,T CT 6X3.5 160
SW814
87-036-251-080
SW,T CT 6X3.5 160
SW815
87-036-251-080
SW,T CT 6X3.5 160
VR801
87-A91-597-010
SW,RTRY SIM-026MT
AUX C.B
J301
87-A61-229-010
JACK,3.5 BLK ST W/SW
6
5
TRANSISTOR ILLUSTRATION
IC BLOCK DIAGRAM-1
IC, LC75374E
IC, KIA6225S
B
E
C
KRA111S
KRA226S
KRC102S
KRC111S
E C B
KTC3198
KTC3203
E C B
DTC343TS
KRA104M
KRA226M
KRC102M
KTA1267
KTA1273
B C E
2SD2395
KTA1046